Skoda Felicia

since 1994 release

Repair and operation of the car


Skoda Felicia
+ Cars of the Skoda Felicia brand
+ Maintenance instruction
- Routine maintenance
   Weekly checks
   + Routine maintenance of the car - petrol models
   - Routine maintenance of the car - diesel models
      Schedule of routine maintenance
      Regular service
      Replacement of motive oil and oil filter
      Removal of a sediment from the fuel filter
      Check of a condition of blocks and disks of forward brake mechanisms
      Check and adjustment of turns of idling
      Check of a condition of hoses, and identification of sources of leaks
      Check of a condition of protective covers of power shafts
      Suspension bracket and drive of steering
      Check of a condition of components of system of production of the fulfilled gases
      Check of a condition of cooling liquid
      Check of serviceability of functioning of coupling
      Greasing of locks and loops
      Check of composition of the fulfilled gases
      Adjustment of an optical axis of head headlights
      Check of serviceability of functioning of cleaners/washers of glasses/lenses of head headlights
      Trial runs
      Replacement of the filtering air cleaner element
      Replacement of the fuel filter
      Check of a condition of a belt of the GRM drive
      Check of a condition of a belt of the drive of auxiliary units
      Check of system of safety cushions
      Check of serviceability of functioning of systems of decrease in toxicity of the fulfilled engine gases
      Check of a condition of boots and drums of back brake mechanisms
      Check of serviceability of functioning of the parking brake
      Check of body panels on existence of traces of development of corrosion
      Check of level of gearbox oil
      Replacement of gearbox oil
      Replacement of a belt of the GRM drive
      Replacement of brake fluid
      Replacement of cooling liquid
+ Repair of the engine
+ Cooling systems, heating
+ Power supply system
+ Engine electric equipment
+ Coupling
+ Transmission
+ Power shafts
+ Brake system
+ Suspension bracket and steering
+ Body and finishing of salon
+ Onboard electric equipment


Replacement of the fuel filter

Components of the fuel filter

1 — the Sealing ring
2 — the Valve of management
3 — a R-shaped clip
4 — the Union

5 — the Fuel filter
6 — the Washer
7 — the Drain gate
8 — the Union


 PERFORMANCE ORDER

1. The fuel filter is installed on the right in a back part of a motive compartment.
2. Get drain capacity under the filter, for collecting the spilled fuel enclose rags.
3. Remove a R-shaped clamp and take the operating valve from the top part of the filter, without disconnecting fuel hoses.
4. Release collars and disconnect fuel hoses from filter unions If for fastening of hoses collars of the twisted type are used, it is necessary to have a bite their bokorezam, and at assembly to replace more practical screw or worm. Try to remember an order of connection of a hose for the purpose of observance of orientation of the replaceable filter in relation to the direction of a stream of fuel.

Be ready to collecting the spilled fuel.

5. By means of a prutkovy key turn out the screw of a fixing arm and remove the filter.

6. Before installation fill the replaceable filter with pure diesel fuel that will help to facilitate initial start of the engine. Install the filter in a fixing arm and strongly record it the screw.
7. Put on a new sealing ring the valve of management and establish the last on the regular place in the top part of the fuel filter. Fix the valve a R-shaped clip.
8. Connect fuel hoses to the filter (pay attention to the arrows on the filter case near its unions specifying the right direction of a stream. Record hoses new collars. Remove the drain capacity and rags. If removed, connect an air sleeve to the air cleaner and the inlet pipeline.
9. Start the engine on single turns and check the filter for existence of signs of leak of fuel.

Start of the engine can take slightly more usual time that is connected with need of filling with fuel of cavities of a path, especially if the new filter was not filled in previously.

10. Several times lift turns till 2000 a minute, at once dumping from back to single. Make sure of lack of bubbles in a fuel stream in the translucent hose connected to TNVD.